| Common Name: | ORIGINAL CONTACT CEMENT BOTTLE |
| Manufacturer: | DAP |
| SDS Revision Date: | 6/19/2015 |
| SDS Format: | GHS-US |
| Grainger Item Number(s): | 1DPB8, 5E094, 5E095, 5E096 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS NUMBER: 00030202001
REVISION DATE: 6/19/2015
DAP(R*)
SAFETY DATA SHEET
24 HOUR EMERGENCY PHONE NUMBERS:
MEDICAL/POISON CONTROL:
IN U.S.:
CALL: 1-800-222-1222
OUTSIDE U.S.: CALL YOUR LOCAL POISON CONTROL CENTER
TRANSPORTATION/NATIONAL RESPONSE CENTER:
1-800-535-5053
1-352-323-3500
NOTE:
THE NATIONAL RESPONSE CENTER EMERGENCY NUMBERS TO BE USED ONLY IN THE EVENT
OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT
INVOLVING CHEMICALS.
IMPORTANT:
PROVIDE THIS INFORMATION TO EMPLOYEES, CUSTOMERS, AND USERS OF THIS
PRODUCT. READ THIS SDS BEFORE HANDLING OR DISPOSING OF THIS PRODUCT. THIS
PRODUCT IS COVERED BY THE OSHA HAZARD COMMUNICATION STANDARD AND THIS
DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH REQUIREMENTS OF THIS
STANDARD. ALL ABBREVIATED TERMS USED IN THIS MSDS ARE FURTHER DESCRIBED
IN SECTION 16.
| 1. IDENTIFICATION |  |
THIS MATERIAL SAFETY DATA SHEET IS AVAILABLE IN AMERICAN SPANISH UPON
REQUEST.
PRODUCT NAME: ORIGINAL CONTACT CEMENT BOTTLE
PRODUCT UPC NUMBER: 00102, 00105
PRODUCT USE/CLASS: CONTACT ADHESIVE
REVISION DATE: 6/19/2015
SUPERCEDES DATE: 7/18/2013
SDS NO: 00030202001
MANUFACTURER:
DAP PRODUCTS INC.
2400 BOSTON STREET
SUITE 200
BALTIMORE, MD 21224-4723
888-327-8477 (NON - EMERGENCY MATTERS)
PREPARER: REGULATORY DEPARTMENT
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER!
EXTREMELY FLAMMABLE LIQUID AND VAPOR. VAPORS MAY CAUSE FLASH FIRE OR
EXPLOSION. VAPORS CAN FORM AN IGNITABLE MIXTURE WITH AIR. VAPORS CAN FLOW
ALONG SURFACES TO A DISTANT IGNITION SOURCE AND FLASH BACK. DO NOT SMOKE.
EXTINGUISH ALL FLAMES AND PILOT LIGHTS, AND TURN OFF STOVES, HEATERS,
ELECTRIC MOTORS AND OTHER SOURCES OF IGNITION DURING USE AND UNTIL ALL
VAPORS ARE GONE. KEEP CONTAINER CLOSED AND AWAY FROM HEAT, SPARKS, AND OPEN
FLAME. STORE AWAY FROM CAUSTICS AND OXIDIZERS. AVOID BREATHING VAPOR. AVOID
SKIN AND EYE CONTACT. USE ONLY WITH ADEQUATE VENTILATION. PREVENT BUILD-UP
OF VAPORS BY OPENING ALL WINDOWS AND DOORS TO ACHIEVE CROSS-VENTILATION.
IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN. HARMFUL OR FATAL IF
SWALLOWED. ASPIRATION HAZARD IF SWALLOWED - CAN ENTER LUNGS AND CAUSE
DAMAGE. MAY AFFECT THE BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE
OR NAUSEA.
GHS CLASSIFICATION:
ACUTE TOX. 4 INHALATION, ACUTE TOX. 4 ORAL, CARC. 1B, EYE IRRIT. 2, FLAM.
LIQ. 1, MUTA. 1B, SKIN IRRIT. 2, STOT RE 2, STOT SE 3 NE, STOT SE 3 RTI
SYMBOL(S) OF PRODUCT:
EXCLAMATION MARK
HEALTH HAZARD
FLAME
SIGNAL WORD: DANGER
GHS HAZARD STATEMENTS:
FLAMMABLE LIQUID, CATEGORY 1:
H224: EXTREMELY FLAMMABLE LIQUID AND VAPOUR.
ACUTE TOXICITY, ORAL, CATEGORY 4:
H302: HARMFUL IF SWALLOWED.
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
ACUTE TOXICITY, INHALATION, CATEGORY 4:
H332: HARMFUL IF INHALED.
STOT, SINGLE EXPOSURE, CATEGORY 3, RTI:
H335: MAY CAUSE RESPIRATORY IRRITATION.
STOT, SINGLE EXPOSURE, CATEGORY 3, NE:
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
GERM CELL MUTAGENICITY, CATEGORY 1B:
H340:
MAY CAUSE GENETIC DEFECTS. CLASSIFIED AS MUTAGENIC CATEGORY 1 IF ONE
INGREDIENT IS PRESENT AT OR ABOVE 0.1% APPLIES TO LIQUIDS, SOLIDS (W/W
UNITS) AND GASES (V/V). THE SUBSTANCE MAY ALSO HAVE ITS OWN EXPOSURE LIMIT.
ROUTES OF EXPOSURE ARE DEPENDANT ON INGREDIENT FORM.
CARCINOGENICITY, CATEGORY 1B:
H350:
MAY CAUSE CANCER. CLASSIFIED AS CARCINOGENIC CATEGORY 1 ON THE BASIS OF
EPIDEMIOLOGICAL AND/OR ANIMAL DATA. MIXTURES ARE CLASSIFIED AS CARCINOGENIC
WHEN AT LEAST 1 INGREDIENT HAS BEEN CLASSIFIED AS CARCINOGENIC AND IS
PRESENT AT 0.1% OR ABOVE ROUTES OF EXPOSURE ARE DEPENDANT ON INGREDIENT
FORM.
STOT, REPEATED EXPOSURE, CATEGORY 2:
H373:
MAY CAUSE DAMAGE TO ORGANS <OR STATE ALL ORGANS AFFECTED, IF KNOWN> THROUGH
PROLONGED OR REPEATED EXPOSURE <STATE ROUTE OF EXPOSURE IF IT IS
CONCLUSIVELY PROVEN THAT NO OTHER ROUTES OF EXPOSURE CAUSE THE HAZARD>.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING.
P260: DO NOT BREATHE DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P281: USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P362: TAKE OFF CONTAMINATED CLOTHING.
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P403+P235: STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
GHS SDS PRECAUTIONARY STATEMENTS:
P240: GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
P241: USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING/.../ EQUIPMENT.
P242: USE ONLY NON-SPARKING TOOLS.
P243: TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
P270: DO NO EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS-NO. WT. % GHS SYMBOLS GHS STATEMENTS
TOLUENE 108-88-3 25-50 GHS02-GHS03- H225-270-302-304-
GHS07-GHS08 315-332-335-
336-373
ACETONE 67-64-1 25-50 GHS02-GHS03- H225-270-319-336
GHS07
LIGHT ALIPHATIC 64742-89-8 10-25 GHS03-GHS06- H270-304-331-
SOLVENT NAPHTHA GHS08 340-350
N-HEPTANE 142-82-5 2.5-10 GHS02-GHS03- H225-270-304-
GHS07-GHS08 315-336
METHYLCYCLO- 108-87-2 1.0-2.5 GHS02-GHS03- H225-270-304-
HEXANE GHS07-GHS08 315-332-336
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - INHALATION:
IF INHALED, REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION
IMMEDIATELY.
NOTE:
ONLY TRAINED PERSONNEL SHOULD ADMINISTER ARTIFICIAL RESPIRATION OR GIVE
OXYGEN.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER FOR 15 MINUTES. GET MEDICAL AID IF SYMPTOMS
PERSIST. REMOVE AND WASH CONTAMINATED CLOTHING. DO NOT TRY TO PEEL THE
SOLIDIFIED MATERIAL FROM THE SKIN OR USE SOLVENTS OR THINNERS TO DISSOLVE
IT. THE USE OF VEGETABLE OIL OR MINERAL OIL IS RECOMMENDED FOR REMOVAL OF
THIS MATERIAL FROM THE SKIN. FLUSH EXPOSED AREA WITH WATER WHILE REMOVING
CONTAMINATED CLOTHING. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. TO
REMOVE FROM SKIN, REMOVE COMPLETELY WITH A DRY CLOTH OR PAPER TOWEL, BEFORE
WASHING WITH DETERGENT AND WATER.
FIRST AID - EYE CONTACT:
IF MATERIAL GETS INTO EYES, FLUSH WITH WATER IMMEDIATELY FOR 15 MINUTES.
CONSULT A PHYSICIAN.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
UNUSUAL FIRE AND EXPLOSION HAZARDS:
ELIMINATE SOURCES OF IGNITION:
HEAT, ELECTRICAL EQUIPMENT, SPARKS AND FLAMES. VAPORS CAN FORM AN IGNITABLE
MIXTURE WITH AIR. VAPORS CAN FLOW ALONG SURFACES TO A DISTANT IGNITION
SOURCE AND FLASH BACK. VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR.
CONTAINERS MAY EXPLODE IF EXPOSED TO EXTREME HEAT. EMPTY CONTAINERS RETAIN
PRODUCT RESIDUE (LIQUID AND/OR VAPOR). VAPOR CAN IGNITE POTENTIALLY CAUSING
AN EXPLOSION.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (NIOSH APPROVED OR
EQUIVALENT) AND FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL EXPOSED
SURFACES. COOL FIRE-EXPOSED CONTAINERS USING WATER SPRAY.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM
| 6. ACCIDENTAL RELEASE MEASURES | |
ENVIRONMENTAL MEASURES: NO INFORMATION
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
NOTE:
REVIEW FIRE HAZARDS BEFORE PROCEEDING WITH CLEAN UP. IMMEDIATELY ELIMINATE
SOURCES OF IGNITION. KEEP PEOPLE AWAY FROM AND UPWIND OF SPILL/LEAK.
CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT. DISPOSE OF
CONTAMINATED ABSORBENT, CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. SCRAPE UP DRIED MATERIAL AND PLACE
INTO CONTAINERS. PREVENT PRODUCT FROM ENTERING DRAINS. SOAK UP WITH INERT
ABSORBENT MATERIAL AND DISPOSE OF AS HAZARDOUS WASTE. READ ALL PRODUCT
INSTRUCTIONS BEFORE USING. PERSONAL PROTECTIVE EQUIPMENT SHOULD INCLUDE
IMPERVIOUS GLOVES, PROTECTIVE EYE WEAR, AND SUITABLE WORK CLOTHES.
| 7. HANDLING AND STORAGE | |
HANDLING:
KEEP OUT OF REACH OF CHILDREN! DO NOT TAKE INTERNALLY. REMOVE ALL SOURCES
OF IGNITION. KEEP AWAY FROM OPEN FLAMES, HOT SURFACES AND SOURCES OF
IGNITION. PROVIDE ADEQUATE VENTILATION. AVOID HEAT, SPARKS AND OPEN
FLAMES. WEAR APPROPRIATE PERSONAL PROTECTION. AVOID BREATHING VAPOR AND
CONTACT WITH EYES, SKIN AND CLOTHING. USE IN WELL VENTILATED AREA. OPEN
ALL WINDOWS AND DOORS OR USE OTHER MEANS TO ENSURE CROSS-VENTILATION AND
FRESH AIR ENTRY DURING APPLICATION AND DRYING. ODOR IS NOT AN ADEQUATE
WARNING FOR HAZARDOUS CONDITIONS. EMPTY CONTAINERS RETAIN PRODUCT RESIDUE
(LIQUID AND/OR VAPOR). VAPOR CAN IGNITE POTENTIALLY CAUSING AN EXPLOSION.
WASH THOROUGHLY AFTER HANDLING. DO NOT USE IN AREAS WHERE STATIC SPARKS
MAY BE GENERATED. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING VAPORS MAY BE HARMFUL OR FATAL. CONSTRUCTION AND REPAIR
ACTIVITIES CAN ADVERSELY AFFECT INDOOR AIR QUALITY. CONSULT WITH
OCCUPANTS OR A REPRESENTATIVE (I.E. MAINTENANCE, BUILDING MANAGER,
INDUSTRIAL HYGIENIST, OR SAFETY OFFICER) TO DETERMINE WAYS TO MINIMIZE
IMPACT.
STORAGE:
STORE AWAY FROM SOURCES OF IGNITION AND HEAT. DO NOT STORE AT TEMPERATURES
ABOVE 120 DEGREES F. STORE CONTAINERS AWAY FROM EXCESSIVE HEAT AND
FREEZING. STORE AWAY FROM CAUSTICS AND OXIDIZERS. KEEP CONTAINERS TIGHTLY
CLOSED.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INGREDIENTS WITH OCCUPATIONAL EXPOSURE LIMITS:
CHEMICAL NAME ACGIH ACGIH- OSHA OSHA
TLV-TWA TLV STEL PEL-TWA PEL-CEILING
TOLUENE 20 PPM TWA N.E. 200 PPM TWA 300 PPM CEILING
ACETONE 500 PPM TWA 750 PPM STEL 1000 PPM TWA N.E.
2400 MG/M3 TWA
LIGHT ALIPHATIC N.E. N.E. N.E. N.E.
SOLVENT NAPHTHA
N-HEPTANE 400 PPM TWA 500 PPM STEL 500 PPM TWA N.E.
HEPTANE, HEPTANE, 2000 MG/M3 TWA
ALL ISOMERS ALL ISOMERS
METHYLCYCLO- 400 PPM TWA N.E. 500 PPM TWA N.E.
HEXANE 2000 MG/M3 TWA
FURTHER ADVICE:
MEL = MAXIMUM EXPOSURE LIMIT
OES = OCCUPATIONAL EXPOSURE STANDARD
SUP = SUPPLIER'S RECOMMENDATION
SK = SKIN SENSITIZER
N.E. = NOT ESTABLISHED
PERSONAL PROTECTION:
RESPIRATORY PROTECTION:
A NIOSH-APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR CARTRIDGE
OR CANISTER MAY BE NECESSARY UNDER CERTAIN CIRCUMSTANCES WHERE AIRBORNE
CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE LIMITS. IF CONCENTRATIONS
EXCEED THE EXPOSURE LIMITS SPECIFIED, USE OF A NIOSH-APPROVED SUPPLIED AIR
RESPIRATOR IS RECOMMENDED. WHERE THE PROTECTION FACTOR IS EXCEEDED, USE OF
A SELF CONTAINED BREATHING APPARATUS (SCBA) MAY BE NECESSARY. IF YOU
EXPERIENCE EYE WATERING, HEADACHE OR DIZZINESS OR IF AIR MONITORING
DEMONSTRATES VAPOR/MIST LEVELS ARE ABOVE APPLICABLE LIMITS, WEAR AND
APPROPRIATE, PROPERLY FITTED RESPIRATOR (NIOSH APPROVED) DURING AND AFTER
APPLICATION. A RESPIRATORY PROTECTION PROGRAM THAT MEETS THE OSHA 1910.134
AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
SKIN PROTECTION: SOLVENT-RESISTANT GLOVES.
EYE PROTECTION: GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE EQUIPMENT:
PROVIDE EYEWASH AND SOLVENT IMPERVIOUS APRON IF BODY CONTACT MAY OCCUR.
HYGIENIC PRACTICES: REMOVE AND WASH CONTAMINATED CLOTHING BEFORE RE-USE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: TAN
PHYSICAL STATE: LIQUID
ODOR: STRONG SOLVENT
ODOR THRESHOLD: NOT ESTABLISHED
DENSITY, G/CM3: 0.85 - 0.85
PH: NOT APPLICABLE
FREEZE POINT, DEG. C: NOT ESTABLISHED
VISCOSITY (MPA.S): NOT ESTABLISHED
SOLUBILITY IN WATER: NOT ESTABLISHED
PARTITION COEFF., N-OCTANOL/WATER: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE, DEG. C: NOT ESTABLISHED
EXPLOSIVE LIMITS, %: N.I. - N.I.
BOILING RANGE, DEG. C: N.I. - N.I.
AUTO-IGNITION TEMPERATURE, DEG. C: NOT ESTABLISHED
MINIMUM FLASH POINT, DEG. C: -42
VAPOR PRESSURE, MMHg: NO INFORMATION
EVAPORATION RATE: FASTER THAN N-BUTYL ACETATE
FLASH METHOD: PENSKY-MARTENS CLOSED CUP
VAPOR DENSITY: HEAVIER THAN AIR
COMBUSTIBILITY: DOES NOT SUPPORT COMBUSTION
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
(IF PRODUCT IS AN AEROSOL, THE FLASH POINT STATED ABOVE IS THAT OF THE
PROPELLANT.)
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
CONDITIONS TO AVOID:
KEEP AWAY FROM OPEN FLAMES, HOT SURFACES AND SOURCES OF IGNITION. KEEP AWAY
FROM OXIDIZING AGENTS, STRONGLY ALKALINE AND STRONGLY ACID MATERIALS IN
ORDER TO AVOID EXOTHERMIC REACTIONS. AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. DO NOT SMOKE.
INCOMPATIBILITY:
OPEN FLAMES, HOT SURFACES AND SOURCES OF IGNITION. KEEP AWAY FROM STRONG
OXIDIZING AGENTS, HEAT AND OPEN FLAMES. EXOTHERMIC REACTION WITH STRONG
ACIDS. STRONG OXIDIZERS, ALKALI METALS AND ALKALINE EARTH METALS MAY CAUSE
FIRES OR EXPLOSIONS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL DECOMPOSITION PRODUCTS, I.E., COX, NOX.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECT OF OVEREXPOSURE - INHALATION:
INHALATION OF VAPORS MAY CAUSE IRRITATION OF THE NOSE, THROAT, LUNGS AND
RESPIRATORY TRACT. INHALATION OF VAPORS IN HIGH CONCENTRATION MAY CAUSE
SHORTNESS OF BREATH (LUNG EDEMA). INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. PROLONGED,
REPEATED OR HIGH EXPOSURES MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION
LEADING TO HEADACHES, NAUSEA, DROWSINESS, DIZZINESS, AND POSSIBLY NARCOSIS.
IN EXTREME CASES, MAY CAUSE LOSS OF CONSCIOUSNESS.
EFFECT OF OVEREXPOSURE - SKIN CONTACT:
HARMFUL IF ABSORBED THROUGH THE SKIN. MAY CAUSE SKIN IRRITATION. PROLONGED
AND REPEATED SKIN CONTACT MAY CAUSE DERMATITIS, DRYING AND DEFATTING DUE TO
THE SOLVENT PROPERTIES.
EFFECT OF OVEREXPOSURE - EYE CONTACT:
MAY CAUSE EYE IRRITATION.
SIGNS AND SYMPTOMS MAY INCLUDE:
PAIN, TEARS, SWELLING, REDNESS AND BLURRED VISION.
EFFECT OF OVEREXPOSURE - INGESTION:
HARMFUL OR FATAL IF SWALLOWED. INGESTION MAY CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING AND DIARRHEA. MAY CAUSE GASTROINTESTINAL
DISTURBANCES WITH DIZZINESS AND CENTRAL NERVOUS SYSTEM DEPRESSION. IF
INGESTED, MAY CAUSE DEPRESSED RESPIRATION. ASPIRATION HAZARD IF SWALLOWED.
ASPIRATION OF MATERIAL INTO THE LUNGS DUE TO VOMITING CAN CAUSE CHEMICAL
PNEUMONITIS, WHICH CAN BE FATAL.
CARCINOGENICITY: NO INFORMATION
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
108-88-3 TOLUENE 636 MG/KG 8390 MG/KG 12.5 MG/L RAT
RAT RABBIT
67-64-1 ACETONE 5250 MG/KG >15688 MG/KG 50 MG/L RAT
MOUSE RABBIT
64742-89-8 LIGHT ALIPHATIC 5000 MK/KG 3000 MG/KG >4.96 MG/L
SOLVENT NAPHTHA MOUSE RABBIT RAT
142-82-5 N-HEPTANE 5000 MG/KG 3000 MG/KG >29.29 MG/L
RAT RABBIT RAT
108-87-2 METHYLCYCLO- 2250 MG/KG 3072 MG/KG 13.15 MG/L
HEXANE MOUSE RAT RAT
N.I. = NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
ECOLOGICAL INJURIES ARE NOT KNOWN OR EXPECTED UNDER NORMAL USE.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
RESIDUES AND SPILLED MATERIAL ARE HAZARDOUS WASTE DUE TO IGNITABILITY.
DISPOSE OF MATERIAL IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. STATE AND LOCAL REGULATIONS/RESTRICTIONS ARE COMPLEX AND MAY
DIFFER FROM FEDERAL REGULATIONS. RESPONSIBILITY FOR PROPER WASTE DISPOSAL
IS WITH THE OWNER OF THE WASTE. LIQUIDS CANNOT BE DISPOSED OF IN A
LANDFILL. DO NOT FLUSH INTO SURFACE WATER OR SANITARY SEWER SYSTEM. DO NOT
EMPTY INTO DRAINS. DO NOT RE-USE EMPTY CONTAINERS. THE CONTAINER FOR THIS
PRODUCT CAN PRESENT EXPLOSION OR FIRE HAZARDS, EVEN WHEN EMPTIED. TO AVOID
RISK OF INJURY, DO NOT CUT, PUNCTURE, OR WELD ON OR NEAR THIS CONTAINER.
| 14. TRANSPORT INFORMATION | |
SPECIAL TRANSPORT PRECAUTIONS: NO INFORMATION
DOT UN/NA NUMBER: UN1133
DOT PROPER SHIPPING NAME: ADHESIVES, CONTAINING A FLAMMABLE LIQUID
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: 3
HAZARD SUBCLASS: N.A.
PACKING GROUP: III
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
FIRE HAZARD, ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
TOLUENE 108-88-3
TOXIC SUBSTANCES CONTROL ACT:
ALL INGREDIENTS IN THIS PRODUCT ARE EITHER ON TSCA INVENTORY LIST, OR
OTHERWISE EXEMPT.
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
CALIFORNIA PROPOSITION 65 CARCINOGENS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL REGULATIONS: AS FOLLOWS
CANADIAN WHMIS:
THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
WHMIS CLASS: CONSUMER COMMODITY
| 16. OTHER INFORMATION | |
REVISION DATE: 6/19/2015
SUPERSEDES DATE: 7/18/2013
REASON FOR REVISION: HAZCOM2012/GHS CONVERSION
DATASHEET PRODUCED BY: REGULATORY DEPARTMENT
HMIS RATINGS:
HEALTH 2
FLAMMABILITY 3
REACTIVITY 0
PERSONAL PROTECTION X
VOC LESS WATER LESS EXEMPT SOLVENT, G/L: 646.5
VOC MATERIAL, G/L: 459
VOC AS DEFINED BY CALIFORNIA CONSUMER PRODUCT REGULATION, WT/WT%: 53.8
TEXT FOR GHS HAZARD STATEMENTS SHOWN IN SECTION 3 DESCRIBING EACH
INGREDIENT:
H225: HIGHLY FLAMMABLE LIQUID AND VAPOUR.
H270: MAY CAUSE OR INTENSIFY FIRE; OXIDISER.
H302: HARMFUL IF SWALLOWED.
H304: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
H315: CAUSES SKIN IRRITATION.
H319: CAUSES SERIOUS EYE IRRITATION.
H331: TOXIC IF INHALED.
H332: HARMFUL IF INHALED.
H335: MAY CAUSE RESPIRATORY IRRITATION.
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
H340:
MAY CAUSE GENETIC DEFECTS <STATE ROUTE OF EXPOSURE IF IT IS CONCLUSIVELY
PROVEN THAT NO OTHER ROUTES OF EXPOSURE CAUSE THE HAZARD>.
H350: MAY CAUSE CANCER.
H373:
MAY CAUSE DAMAGE TO ORGANS <OR STATE ALL ORGANS AFFECTED, IF KNOWN> THROUGH
PROLONGED OR REPEATED EXPOSURE <STATE ROUTE OF EXPOSURE IF IT IS
CONCLUSIVELY PROVEN THAT NO OTHER ROUTES OF EXPOSURE CAUSE THE HAZARD>.
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
GHS02: FLAME
GHS03: FLAME OVER CIRCLE
GHS06: SKULLS AND CROSSBONES
GHS07: EXCLAMATION MARK
GHS08: HEALTH HAZARD
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
DAP BELIEVES THE DATA AND STATEMENTS CONTAINED HEREIN ARE ACCURATE AS OF
THE DATE HEREOF. THEY ARE OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT
AS A PRODUCT SPECIFICATION. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF
FITNESS FOR ANY PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR
IMPLIED, IS MADE WITH REGARD TO THE INFORMATION HEREIN PROVIDED OR THE
PRODUCT TO WHICH THE INFORMATION REFERS. SINCE THIS DOCUMENT IS INTENDED
ONLY AS A GUIDE TO THE APPROPRIATE USE AND PRECAUTIONARY HANDLING OF THE
REFERENCED PRODUCT BY A PROPERLY TRAINED PERSON, IT IS THEREFORE THE
RESPONSIBILITY OF THE USER TO (I) REVIEW THE RECOMMENDATIONS WITH DUE
CONSIDERATION FOR THE SPECIFIC CONTEXT OF THE INTENDED USE AND (II)
DETERMINE IF THEY ARE APPROPRIATE.